Product ID:CURING SOLUTION FOR 463-06, CA 97
MSDS Date:04/10/1989
FSC:1615
NIIN:01-087-1397
Kit Part:Y
MSDS Number: BJFRN

AKZO COATINGS INC

434 W MEATS AVE
ORANGE, CA 92665
US

Emergency Phone: 15P.M.)

Info Phone: 213-855-7313 (AFTER HOURS)

Cage: 98502

BOEING HELICOPTERS, DIV OF THE BOEING CO

RIDLEY PARK, PA 19078 US

Telephone: 215-591-3010

Cage: 77272

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 40-55%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 45-60%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE IRRIT,CONTACT MAY CAUSE EYE
BURNS OR CORNEAL INJURY.EXCESSIVE INHAL OF VAPS CAN CAUSE NASAL &
RESP IRRIT,DIZZINESS,WEAKNESS,FATIGUE,NAUSEA,HEADACHE,POSSIBLE
UNCON,& ASPHYXIATION.MILD SKIN IR RIT.INGEST:GI
IRRIT,NAUSEA,VOMIT,DIARRHEA,DEPRESSION.(SEE EFTS OF OVEREXPOSURE)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:(HLTH HAZ CON'T):EYE CNTCT:SEVERE
IRRIT,REDNESS,TEARING,BLURRED VISION.ASPIR INTO LUNGS CAN CAUSE
CHEM PNEUM/CAN BE FATAL.CHRONIC:REPEATED OVER EXPOS MAY RESULT IN
DELAYED KIDNEY INJURY.PETROLEUM HYDR OCARBONS POSE POTENTIAL HUMAN
HEALTH RISKS WHICH MAY VARY FROM PERSON TO PERSON,MIN EXPOS TO LIQ
VAPS.LIVER ABNORM.
Medical Cond Aggravated by Exposure:NONE EXPECTED.

First Aid:INHAL:MOVE TO FRESH AIR, GIVE ART RESP IF NECESSARY.
SKIN:WASH W/SOAP & WATER. EYE:FLUSH W/WATER AT LEAST 15 MIN, GET
MD. INGEST:DRINK ONE OR TWO GLASSES OF WATER TO DILUTE. DO NOT
INDUCE VOMIT. GET M D OR POISON CONTROL CENTER IMMEDIATELY.TREAT
SYMPTOMATICALLY.

Flash Point Method:TCC
Flash Point:40.0F,4.4C
Lower Limits:1.2
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:WATER MAY BE INEFCT.WATER SHOULD BE USED TO
COOL CNTRS EXPSD TO FIRE.FIRE FIGHTING PERSONNEL SHOULD WEAR
NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD.ISOLATE FROM
HEAT,SPARKS,ELEC EQUIP/OPEN FLAME.CLSD CONTRS MAY EXPLODE WHEN
EXPSD TO EXTREME HEAT.DECOMP PROD MAY CAUSE HEALTH HAZARD.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION.AVOID BREATHING
VAPORS.VENTILATE AREA. REMOVE WITH INERT ABSORBENT. REFER TO
PROTECTIVE MEASURES LISTED THROUGHOUT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE CONTRS OUT OF SUN & AWAY FROM
HEAT,SPARKS & OPEN FLAMES.CLOSE CONTRS AFTER EACH USE.CONSULT NFPA
CODE FOR ADDITIONAL STORAGE REQUIREMENTS.
Other Precautions:DO NOT TAKE INTERNALLY.USE APPROVED BONDING &
GROUNDING PROCEDURES.OBSERVE LABEL PRECAUTIONS.KEEP CLOSURES TIGHT
& CONTR UPRIGHT TO PREVENT LEAKAGE.NEVER USE PRESSURE TO
EMPTY.AVOID BREATHING DUST.DO NOT WELD OR FLAME CUT EMPTY DRUM.

Respiratory Protection:ADEQUATE VENTILATION IS REQUIRED.USE NIOSH/MSHA
APPROVED RESPIRATOR DEVICE.SEE SAFETY EQUIP SUPPLIER FOR EVALUATION
& RECOMMENDATION.IN CONFINED AREAS, USE NIOSH/MSHA APPROVED AIRLINE
RESPIRATOR OR HO OD.
Ventilation:SUFFICIENT TO KEEP VAPOR CONC BELOW TLV & LEL.FOR BAKING
FINISHES,EXHAUST VAPS.REMOVE DECOMP PROD FORMED DURING WELDING.
Protective Gloves:REFER TO SAFETY EQUIPMENT SUPPLIER.
Eye Protection:CHEM WORKERS GOGG,FACESHIELD OPTNL
Other Protective Equipment:EYE BATH & SHOWER. CHEM RESISTANT APRON,
BOOTS OR OTHER CLOTHING TO AVOID REPEATED OR FREQUENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM.
Supplemental Safety and Health
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS MAY BE HARMFUL OR FATAL.REPORTS HAVE ASSOCIATED REPEATED &
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE.DO NOT HANDLE UNTIL THE MANUFACTURERS SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.

Boiling Pt:B.P. Text:180F,82C
Vapor Pres:SEE INGRED
Vapor Density:HEAVR/AIR
Spec Gravity:0.837
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIQUID, PAINT
Percent Volatiles by Volume:92.2

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SMOKE, OXIDES OF NITROGEN.

Waste Disposal Methods:INCINERATE IN AN APPROVED FACILITY, DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF I/A/W FEDERAL, STATE AND
LOCAL POLLUTION CONTROL REQUIREMENTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.